WESTSAIL SERVICE MANUAL
CHAPTERS
- MAST AND RIGGING
- RAILS, BOWSPRIT, BOOMKIN
- EXTERIOR HARDWARE
- HULL AND DECK, GELCOAT, BOTTOM
- INTERIOR
- ENGINE, SHAFT, PROP
- PLUMBING, TANKS
- ELECTRICAL AND ELECTRONICS
- MISCELLANEOUS INFORMATION
- COPIES OF MAGAZINE ARTICLES
CONTENTS
A. MAST AND RIGGING
- TUNING THE MAST RIGGING
- REPLACEMENT RUNNING RIGGING
- REPLACEMENT STANDING RIGGING
- SPLIT BACKSTAYS ATTACHED TO HULL
- FORESTAY RELEASE LEVER
- TURNBUCKLES
- CHAINPLATES
- BOBSTAY FITTING
- BOOMKIN STAY TANG FAILURES
- BOOMKIN CROSSPIECE FAILURES ON WESTSAIL 32
- BOWSPRIT ATTACHMENT AND STAYSAIL EYEBOLT
- BOBSTAY WIRE FAILURES
- RUNNING BACKSTAYS
- FURLING GEAR
- JIFFY REEFING KIT
- WINCH REPLACEMENT
- BOOM VANG
- CRUISING SPINNAKERS
- MAST SUPPORT PROBLEM ON WESTSAIL 32
- MAINSHEET TRAVELER TRACK SYSTEM
- MAST LOWERING WITH A TABERNACLE BASE
- TABERNACLE MAST BASE CONVERSION
- BOOM GOOSENECK
- SAILPLAN
B. RAILS, BOWSPRIT, BOOMKIN
- WOODEN BOWSPRIT DELAMINATION AND DRY ROT
- STAINLESS STEEL BOX BOWSPRIT
- WESTSAIL 32 STAINLESS STEEL PIPE BOWSPRIT
- STAINLESS STEEL BOWSPRIT INSTALLATION
- WESTSAIL 32 STAINLESS STEEL BOOMKIN
- WESTSAIL 32 STAINLESS STEEL BOOMKIN INSTALLATION
- WESTSAIL 32 STERN PULPIT
- MAINSHEET HOOP AND FIDDLE BLOCK
- WESTSAIL 28 STERN PULPIT
- LONG DOUBLE RAIL BOW PULPIT
- BRACED MAST RAILS OR MAST PULPITS
- BOOM GALLOWS
- WESTSAIL PULPITS, RAILS, STANCHIONS AND LIFELINES
C. EXTERIOR HARDWARE
- HAWSE PIPES
- SCUPPER DRAIN TUBES
- PORTLIGHT GLASS, SCREENS AND GASKETS
- GENOA TRACK
- SPLIT COCKPIT FLOOR MODIFICATION
- COCKPIT FLOOR HATCH
- CABIN TOP ALUMINUM HATCHES
- BIMINI TOP AND DODGER
- LOOSE FOOTED STAYSAIL TRACK
- ANCHOR ROLLERS AND FRAMES
- ANCHOR CHAIN, MOORING PENNANT, AND WINDLASS
D. HULL AND DECK, GELCOAT, BOTTOM
- HULL NUMBERS
- CENTERLINE BONDING OF HULL AND UNDERWATER SEAM LINES
- GELCOAT DEGRADATION WITH AGE
- CABINTOP NONSKID
- OSMOTIC BLISTERING
- DECK SEAM CAULKING AND PLUG REPAIR
- FIBERGLASS RUDDER GUDGEONS
- W-32 STAINLESS STEEL PINTALS AND GUDGEONS
- RUDDER WASHERS
- WESTSAIL RUDDERS
- RUDDER LINE PREVENTER
- TILLERS
- AUTOPILOT INSTALLATION
- BALLAST
E. INTERIOR
- ICEBOX INSULATION
- INSULATION FOR HULL AND CABIN
- PROPANE TANK LOCATION AND STOVE CONVERSION
F. ENGINE, SHAFT, PROP
- WESTSAIL 32 BROKEN ENGINE MOUNT BRACKETS
- ENGINE MOUNTS
- ENGINE CHOICES FOR RE-POWERING A WESTSAIL 32
- ENGINE SPEEDS, VIBRATION, AND BOAT SPEED
- PROPELLER CHOICES
- REPLACING A SHAFT BEARING
- INSTALLATION OF THE SHAFT LOG AFTER REPLACING AN ENGINE
- EXHAUST SYSTEMS
- PERKINS M-35 ENGINE FOR WESTSAIL 32
- PERKINS M-50 ENGINE FOR WESTSAIL 32
- SMALL ENGINE PAN MODIFICATION FOR PERKINS M-50
- FULL ENGINE ROOM LINER MODIFICATION FOR PERKINS M-50
G. PLUMBING, TANKS
- WESTSAIL 32 FUEL TANKS
- WESTSAIL 32 FUEL TANK REPLACEMENT PROCEDURE
- W-42 AND W-43 TANK REPLACEMENT
- ALUMINUM TANK ELECTROLYSIS
- SEACOCKS AND REPLACEMENT CONES
- POLYETHYLENE WATER TANK FOR WESTSAIL 32
- POLYETHYLENE HOLDING TANK
H. ELECTRICAL AND ELECTRONICS
- ELECTRICAL GROUNDING SYSTEMS ON A SAILBOAT
- MAST ELECTRICAL WIRING PROBLEMS AND GROUND FAULT CHECK
- ELECTROLYSIS
- ALTERNATOR DIODE AND FUSE
J. MISCELLANEOUS INFORMATION
- CORROSION AND FAILURES IN STAINLESS STEEL FITTINGS
- LEAKS AND DRY ROT
- HULL BLISTERS
- BOAT VALUES AND INSURANCE
- SOME RANDOM OBSERVATIONS AFTER MANY SURVEYS
- LARGE AND SMALL MUSTS ON A CRUISING BOAT
- MANUALS
- TILLER LOADS, SAIL TRIM, AND BALANCE
- MAST SERVICING
- SURVEY INFORMATION AND COSTS
K. COPIES OF MAGAZINE ARTICLES
- WEAVING THE DREAM
- PRACTICAL SAILOR USED BOAT SURVEY OF WESTSAIL 32
- LATITUDE 38 ARTICLE ON WESTSAIL 32
- MODERN DAY CLASSIC - THE WESTSAIL 32
- RACING THE CRUISING SAILBOAT TO WIN
- SLOW BOAT TO HAWAII - NO WAY
WORLDCRUISER SURVEYS
[Back To Home Port]